CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
Description
Active
REAR FOG LAMP REQUEST
IGNITION SWITCHED GROUND
SIDE LAMP REOUEST
RH TAIL LAMP SUPPLY
STARTER ENGAGE REQUEST
REAR FOG LAMP STATUS
TRAILER RH DI LAMP SUPPLY
LH DI LAMP SUPPLY
LH TAIL LAMP SUPPLY
HAZARD LAMP REQUEST
RH DI REOUEST
TRAILER LH Dl LAMP SUPPLY
RH DI LAMP SUPPLY
BATTERY SUPPLYVOLTAGE
BATTERY SUPPLY VOLTAGE
SCP NETWORK
SCP NETWORK
LH DI REQUEST
SIDE MARKER&NUMBER PLATE LAMP RELAYACTlVATE
HAZARD LAMP STATUS
BATTERY SUPPLY VOLTAGE
GROUND
GROUND
GROUND
B+
GROUND ICRANKING)
GROUND
B- (PULSEDI
B- (PULSEDI
BA
GROUND ,MOMENTARYi
GROUND
B+ (PULSED)
B+ (PULSED)
B+
87
2 1600 Hz
2 - 1600 Hz
GROUND
GROUND
GROUND (PULSE,
B+
INSTRUMENT PACK
I7 Pin
Description
Active
S
FC24-19
SCP NETWORK
2 - 1600 Hz
S FC24-20
SCP NETWORK
2 - ,600 Hz
C
FC-24.24
CAN NETWORK
15- 1500 Hz
C
FC24-47
CAN NETWORK
1551500HZ
SECURITY AND LOCKING CONTROL MODULE
v Pin
Description
Active
0 BT,-3
0
BT,-4
0 BTV5
I BT,-6
0
BTI-7
S BTM
0 BT,-9
I BT,-13
I BTI-14
S
811~16
RH STOP LAMP SUPPLY
REAR FOG LAMP SUPPLY
REVERSE LAMP SUPPLY
BATTERY SUPPLY
SPLIT CHARGE CONTROL
SCP NETWORK
LH STOP LAMP SUPPLY
LOGIC GROUND
LOGIC GROUND
SCP NETWORK
B+
B+
B+
B+
2 1600 Hz
B+
GROUND
GROUND
2 - ,600 Hz
I 872-l
BRAKE SWITCH STATUS
GROUND iBRAKE ONi
I BT2-6
TRAILER CONNECTION STATUS
GROUND (TRAILER PRESENT)
NOTE: REFER TO THE APPENDIX AT THE REAR OF THIS BOOK FOR CAN AND SCP NETWORK MESSAGES.
Inactive
B-
B+
B+
GROUND
B+
B+
GROUND
GROUND
GROUND
B+
B+
GROUND
GROUND
B+
B+
B+
B+
B+
B+
Inactive
Inactive
GROUND
GROUND
GROUND
B+
GROUND
GROUND
GROUND
B+
B+ (NO TRAILER)
COMPONENTS
Component
BODY PROCESSOR MODULE
BRAKE SWITCH
CENTER CONSOLE SWITCH PACK
DIODE iBT.+X- NUMBER PLATE
FOG LAMP SWITCHES
FUSE BOX-TRUNK
HIGH MOUNTED STOP LAMP
INSTRUMENT PACK
LlGHTiNG STALK (COLUMN SWITCHGEAR)
NUMBER PLATE LAMP- LH
NUMBER PLATE LAMP- RH
REAR SIDE MARKER - LH
REAR SIDE MARKER - RH
SECURITY AND LOCKING CONTROL MODULE
TAIL LAMP UNIT- iH
TAIL LAMP UNIT- RH
TRAILER CONNECTOR
Connector I Type / Color
FC15,14~WAYAMP EEEC,GREY
CC40, h-WAY MULTliOCK 070 /WHITE
CC,, 16.WAY FORD IDC S.U., BLACK
BT.40, ?-WAY DlODE MODULE ASSEMBLY
FC3, >&WAY AMP MICRO QUAD LOCK, NATURAL
BTlO, IO~WAY U.T A. FUSE BOX, NATURAL
BTi l/10-WAY UT A. FUSE BOX: BLACK
BT12,10-WAY U T A. FUSE BOX, GREEN
BT13,10-WAY U T.A. FUSE BOX, BLUE
BT64, EYELET
CA35, Z-WAY YAZAKI , NATURAL
FCZ4,48-WAY AMP MODULE PCB SiGNAL, BLACK
FCZS, 24.WAY AMP MODULE PCB SIGNAL, BLACK
SC?, 10.WAY MULTILOCK 070 /YELLOW
BT27, Z-WAY AMP POSlLOCK I,, BLACK
BT26, Z-WAY AMP POSiLOCK II, BLACK
BT29, V.VAY RElNSHAGEN, VOLKSWAGEN, BLACK
8731, ?-WAY RElNSHAGEN , VOLKSWAGEN, BLACK
BT1,1&WAY FORD 2 8 TIMER, BLACK
BT2, ZWAY FORD IDC, BLACK
BT6, VWAY COAXIAL CONNECTOR
8751, ,-WAY FRAM - FORD 2.8 TIMER, BLACK
BT50, ,-WAY FRAM - FORD 2.4 TIMER, BLACK
BT32,14~WAY MULTiLOCK 070, YELLOW
Location / Access
BULKHEAD, BEHIND GLOVE BOX
ADJACENT TO THE BRAKE PEDAL MOUNTING ASSEMBLY
CENTER CONSOLE SWITCH PACK
ADJACENTTO BAITERY, BATTERY COVER
FASCIA/OUTBOARD OF STEERING COLUMN
TRUNK ELECTRICAL CARRIER
BACKLIGHT
FASClA
COLUMN SWITCHGEAR HARNESS,
ADJACENTTO STEERiNG COLUMN MOTOR
BEHIND TRUNK LID LINER
BEHIND TRUNK LID LINER
TRUNK LH SIDE, TRUNK CARPET
TRUNKRH SIDE,TRUNKCARPET
BELOW TRUNK FUSE BOX
TRUNK LH SIDE, REAR LAMP COVER
TRUNK RH SIDE, REAR LAMP COVER
ABOVE TRUNK FUSE BOX
RELAYS
Relay
Case Color
Connector / Color
Location / Access
STOP LAMP RELAY
SIDE MARKER AND NUMBER PLATE iPlMP RELAY
BROWN BUS
RELAY#S, TRUNK FUSE BOX/TRUNK
BROWN
BUS RELAY#%TRUNKFUSEBOX,TRUNK
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BT4
CA19
FC,
FC5
FC7
54.WAY THROUGH PANEL, BLACK
PO-WAY MULTILOCK 070 /YELLOW
SI-WAYTHROUGH PANEL CONNECTOR, BLACK
54.WAY THROUGH PANEL CONNECTOR, BLACK
?-WAY MULTILOCK 070, WHITE
BELOW PARCELSHELFiTRUNKiREAR B”LKHEAD,RHSIDE
LH ‘fi POST CONNECTOR MOUNTiNG BRACKET, LOWER ‘A’ POST FlNlSHER
BELOW PASSENGER SlDE AIR VENT, GLOVE BOX ASSEMBLY
BELOW DRIVER SIDE AIR VENT, COIN TRAY
ABOVE DlMMER MODULE, COIN TRAY
GROUNDS
Ground
BT20
BT20
BT21 L
BT22L
CAllL
CC%
CCBR
FC17L
FCliR
Location / Type
EYELET (SINGLE, - TRUNK, RH REAR GROUND STUD
EYELET (SINGLE, - TRUNK, RH REAR GROUND STUD
EYELET (PAIR) -TRUNK, RH REAR GROUND STUD
EYELET iPAiR, - TRUNK, RH CENTER GROUND STUD
EYELET ,PAIRI - RH DRIVE SHAFTTUNNEL GROUND STUD
EYELET iPAIR, - RH FRONT BULKHEAD STUD, CABIN SIDE
EYELET iPAIR, - RH FRONT BULKHEAD STUD, CABIN SIDE
EYELET IPAIR) - EMS BULKHEAD GROUND STUD
EYELET (PAIR) - EMS BULKHEAD GROUND STUD
CONTROL MODULE PIN OUT INFORMATION (FOLD OUT PAGE)
+
The following symbols are used to represent values for Control Module Pin Out data:
I
Input
D Serial and encoded communications
0 output
B+ Battery voltage
KHz Frequency x 1000
C CAN (Network)
SG Signal Ground
V Voltage (DC)
MS Milliseconds
S SCP Network
Hz Frequency
MV Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
REFER TO THE FRONT OF THE BOOK FOR ILLUSTRATIONS DETAILING THE LOCATION AND IDENTIFICATION OF COMPONENTS, RELAYS,
CONNECTORS, HARNESSES, GROUNDS, VEHICLE CONTROL MODULES AND CONTROL MODULE PINS.
DATE OF ISSUE: SEPTEMBER 1997
