Filter
Top Products
TURNING THE WALKING PLATFORM
Both sides of the walking platform are designed to be used as walking surfaces. Inspect the walking platform peri-
odically for wear. If there is any wood showing through the phenolic coating, or if the surface is damaged, the
walking platform should be turned over. The walking platform will need to be turned over after every 6,000 to
7,500 miles. Follow the instructions below to turn over the walking platform.
1. Remove the key and unplug the
power cord. Remove the two
Hood Screws (2) and lift off the
Motor Hood (1). Next, remove the
two Rear Roller Bolts (82), the
two Roller Guard Screws (80),
and the Right and Left Roller
Guards (81, 83).
2. Remove the six Platform Screws
(6). Lift the Rear Roller (79) and
slide it out of the Walking Belt
(71). Lift the Walking Platform
(70) a few inches, slide it out of
the Walking Belt, turn it over, and
then slide it back into the Walking
Belt. Slide the Rear Roller back
into the Walking Belt. Reattach
the six Platform Screws (6).
3. Reattach the Right and Left Roller Guards (81, 83) with the two Roller Guard Screws (80). Insert the Rear
Roller Bolts (82) into the Roller Guards and thread them into the Rear Roller (79). Reattach the Motor Hood
(1) with the two Hood Screws (2).
4. Next, the Walking Belt (71) will need to be adjusted to the
proper tension. Using chalk, make two marks on the
Walking Belt exactly 50” apart, as shown in the drawing.
Tighten both Rear Roller Bolts (82) until the two chalk
marks move apart an additional 3/16” to 1/4”. Make sure to
keep the Walking Belt centered.
REPLACING THE WALKING PLATFORM
When both sides of the walking platform become worn, the walking platform should be replaced. The walking
platform will need to be replaced after every 12,000 to 15,000 miles. Refer to page 44 to order a new walking plat-
form. Follow the instructions above to replace the walking platform.
REPLACING THE WALKING BELT
When the walking belt becomes worn, it should be replaced. The walking belt will need to be replaced after every
12,000 to 15,000 miles. Refer to page 44 to order a new walking belt.
30
6
6
6
80
80
82
82
70
79
71
1
2
81
83
50”
4
71
82
1–3