Reelmaster 6500-D/6700-D
Page 5 - 10
Electrical System (Rev. C)
Note: If machine must be operable with leak detector
disabled, unplug leak detector 4--pin connector from
4--pin connector of main harness. Do not unplug leak
detector alarm.
If false alarms are observed:
1. Oil level may be low causing air to be drawn out of
system. Check oil level.
2. Extremely hard left turns cancause oilto sloshto the
right, exposing suction line and purging air out of sys-
tem. Normal maneuvering should not cause this condi-
tion.
3. Airleakinsystem.Checktomakesurecapissecure-
lyon tank.Contact your local authorizedToroDistributor
for further assistance with air leak problem.
4. To check for a system problem, install hand held
Diagnostic ACE, toggle input/output and check for any
problems previously discussed.
Note: The system will reset itself whenever the
ignition key is turned to “OFF” position. The hand held
Diagnostic ACE must be connected and observed
during a false alarm. Once the ignition key is turned to
“OFF” position, the TurfDefender will reset itself.
5. Your Authorized Toro Distributor has equipment to
analyze system problems.
IMPORTANT: The Diagnostic ACE displays must
not be left connected to the machine. It is not de-
signed to withstand the environment of the ma-
chine’s every dayuse. When done usingDiagnostic
ACE, disconnect themfrom the machineand recon-
nect loopback connectors to harness connectors.
Machine will not operate without loopback connec-
tors installed on harness. Store Diagnostic ACE in
dry, secure location in shop, not on machine.
TURFDEFENDER LEAK DETECTOR
2D 1B
3B 2C
1E 2E
1C
3C 2A
2F 1F 3F
ABCD
AA
BB
CC
EE
ELECTRIC
SOLENOID
VALVE
RED/W
BLK/W
TOLEAK DETECTOR CONNECTOR
OFMAIN HARNESS
RED/Y
BLK/Y
+
--
(RED)
ALARM
TURFDEFENDER
COMMUNICATION
PORTAND
LOOPBACK
CONNECTOR
YELLOW
BLK/OR
GN/WT
BLK
BLK/BU
TURFDEFENDER
LOOPBACKI.D.
DECAL
OR/BLK
BLK
RED
Figure 12
1. Electrical Schematic - Optional TurfDefender Leak Detector
